A Novel Thermal Effect Minimization Method on Water Bath System Using F²PID Controller

International Journal of Electrical and Electronics Engineering

© 2023 by SSRG - IJEEE Journal

Volume 10 Issue 12

Year of Publication : 2023

Authors : Pankaj Mohindru

10.14445/23488379/IJEEE-V10I12P111

How to Cite?

Pankaj Mohindru, "A Novel Thermal Effect Minimization Method on Water Bath System Using F²PID Controller," SSRG International Journal of Electrical and Electronics Engineering, vol. 10,  no. 12, pp. 102-113, 2023. Crossref, https://doi.org/10.14445/23488379/IJEEE-V10I12P111

Abstract:

The Water Bath System (WBS) may comprise a single or a mixture of substances used in clinical laboratories. Temperature is the most often varying parameter in the WBS that can affect the production of different products. Therefore, to deal with the temperature control of WBS, a Fuzzy Fractional Order Proportional Integral Derivative Controller (F2PID) is proposed in this paper. The proposed F2PID controller combines the advantage of a Fractional Order Proportional Integral Derivative (FOPID) controller and a Fuzzy Logic Controller (FLC). In the proposed F 2PID, the controlling parameters of FOPID are tuned by fuzzy logic that chooses optimum parameters of the proportional, integral, and derivative gains are 3, 0, and 1, respectively. The WBS is implemented in the MATLAB/Simulink platform, and the results are compared with existing controllers under different set points. The comparative analysis shows that the proposed controller is well suited for the application with different temperature set points.

Keywords:

Water Bath System, Temperature, Set point, Transducer, Fuzzy rules, Heater, Error deviation.

References:

[1] Laveet Kumar, M. Hasanuzzaman, and N.A. Rahim, “Global Advancement of Solar Thermal Energy Technologies for Industrial Process Heat and Its Future Prospects: A Review,” Energy Conversion and Management, vol. 195, pp. 885-908, 2019.
[CrossRef] [Google Scholar] [Publisher Link]
[2] Barbooti M.M., Ibrahim N.K., and Alwan A.H., “Design of Experiments for the Optimization of Biochemical Treatment of Tannery Wastewater,” Journal of Bacteriology & Mycology: Open Access, vol. 5, no. 4, pp. 328-333, 2017.
[CrossRef] [Google Scholar] [Publisher Link]
[3] Rastegar Saeed et al., “Experimental Investigation of the Increased Thermal Efficiency of an Indirect Water Bath Heater by Use of Thermosyphon Heat Pipe,” Thermal Science, vol. 24, no. 6B, pp. 4277-4287, 2020.
[CrossRef] [Google Scholar] [Publisher Link]
[4] Seyyed Reza Razavi, Mehran Sadeghalvaad, and Samad Sabbaghi, “Experimental Investigation on the Stability and Thermophysical Properties of Al2O3/DW and CuO/DW Nanofluids to be Utilized in an Indirect Water Bath Heater,” Journal of Thermal Analysis and Calorimetry, vol. 142, pp. 2303-2318, 2020.
[CrossRef] [Google Scholar] [Publisher Link]
[5] Warji et al., “Portable Water Bath to Support Nanofibrils Processing,” IOP Conference Series: Earth and Environmental Science, vol. 355, 2019.
[CrossRef] [Google Scholar] [Publisher Link]
[6] Mir Ali Farajzadeh, Ali Shahedi Hojghan, and Mohammad Reza Afshar Mogaddam, “Development of a New Temperature-Controlled Liquid Phase Microextraction Using Deep Eutectic Solvent for Extraction and Preconcentration of Diazinon, Metalaxyl, Bromopropylate, Oxadiazon, and Fenazaquin Pesticides from Fruit Juice and Vegetable Samples Followed by Gas Chromatography-Flame Ionization Detection,” Journal of Food Composition and Analysis, vol. 66, pp. 90-97, 2018.
[CrossRef] [Google Scholar] [Publisher Link]
[7] Wanwan Fu et al., “Thermal Properties and Thermal Conductivity Enhancement of Composite Phase Change Material Using Sodium Acetate Trihydrate–Urea/Expanded Graphite for Radiant Floor Heating System,” Applied Thermal Engineering, vol. 138, pp. 618-626, 2018.
[CrossRef] [Google Scholar] [Publisher Link]
[8] Cheng Li et al., “Current in Vitro Digestion Systems for Understanding Food Digestion in Human Upper Gastrointestinal Tract,” Trends in Food Science & Technology, vol. 96, pp. 114-126, 2020.
[CrossRef] [Google Scholar] [Publisher Link]
[9] Yanti Kusumawardani, Endang Dian Setioningsih, and Dyah Titisari, “Water-Bath Calibration Device with Data Storage Using Six Thermocouple Sensor,” Journal of Electronics, Electromedical Engineering, and Medical Informatics, vol. 2, no. 2, pp. 40-47, 2020.
[CrossRef] [Google Scholar] [Publisher Link]
[10] Sudipta Chakraborty et al., “Design of a Simple Temperature Transmitter Circuit of an Electric Heater-Operated Water Bath,” IEEE Sensors Journal, vol. 18, no. 8, pp. 3140-3151, 2018.
[CrossRef] [Google Scholar] [Publisher Link]
[11] Chu Wang et al., “Experimental Study on Composition Evolution of Biomass Pyrolysis Vapors with Condensing Temperature in a Vertical Tubular Condenser,” Bioresource Technology, vol. 307, 2020.
[CrossRef] [Google Scholar] [Publisher Link]
[12] J.S. Madugu, and P.G. Vasira, “Modeling and Performance Evaluation of P, PI, PD and PID Temperature Controller for Water Bath,” American Academic Scientific Research Journal for Engineering, Technology, and Sciences, vol. 47, no. 1, pp. 186-200, 2018.
[Google Scholar] [Publisher Link]
[13] Sohaib Aslam et al., “Temperature Control of Water-Bath System in Presence of Constraints by Using MPC,” International Journal of Advanced and Applied Sciences, vol. 3, no. 12, pp. 62-68, 2016.
[CrossRef] [Google Scholar] [Publisher Link]
[14] Enkh-Amgalan Boldbaatar, and Chih-Min Lin, “Self-Learning Fuzzy Sliding-Mode Control for a Water Bath Temperature Control System,” International Journal of Fuzzy Systems, vol. 17, no. 1, pp. 31-38, 2015.
[CrossRef] [Google Scholar] [Publisher Link]
[15] Bharat Bhushan, Ajit Kumar Sharma, and Deepti Singh, “Fuzzy & ANFIS-Based Temperature Control of Water Bath System,” 2016 IEEE 1st International Conference on Power Electronics, Intelligent Control and Energy Systems (ICPEICES), Delhi, India, pp. 1-6, 2016.
[CrossRef] [Google Scholar] [Publisher Link]
[16] Aaron Don M. Africa, Arl Marion Josef L. Divino, and Kyle Austin B. Hartigan-Go, “Fuzzy Logic Temperature Control: A Feedback Control System Implemented by Fuzzy Logic,” International Journal of Emerging Trends in Engineering Research, vol. 8, no. 5, pp. 1879-1885, 2020.
[CrossRef] [Google Scholar] [Publisher Link]
[17] Tianhai Lu et al., “Intelligent Modeling and Design of a Novel Temperature Control System for a Cantilever-Based Gas-Sensitive Material Analyzer,” IEEE Access, vol. 9, pp. 21132-21148, 2021.
[CrossRef] [Google Scholar] [Publisher Link]
[18] Abdul Wahid Nasir, Idamakanti Kasireddy, and Arun Kumar Singh, “IMC Based Temperature Control of a Water Bath System Modeled as Integer and Non-Integer System,” 2018 International Conference on Recent Trends in Electrical, Control, and Communication (RTECC), Malaysia, pp. 275-280, 2018.
[CrossRef] [Google Scholar] [Publisher Link]
[19] Adeel Ahmad Jamil et al., “Fractional-Order PID Controllers for Temperature Control: A Review,” Energies, vol. 15, no. 10, pp. 1-28, 2022.
[CrossRef] [Google Scholar] [Publisher Link]
[20] Zainul Abidin et al., “Water Bath Sonicator Integrated with PID-Based Temperature Controller for Flavonoid Extraction,” TELKOMNIKA (Telecommunication Computing Electronics and Control), vol. 18, no. 2, pp. 970-976, 2020.
[CrossRef] [Google Scholar] [Publisher Link]
[21] Long Wang et al., “Effect of Rotary Evaporator Water Bath Temperature on the Recovery Rate of Phthalate Esters,” Bulletin of Environmental Contamination and Toxicology, vol. 101, pp. 810-813, 2018.
[CrossRef] [Google Scholar] [Publisher Link]
[22] Sohaib Aslam et al., “PLC Based Model Predictive Control for Industrial Process Control,” International Journal of Advanced and Applied Sciences, vol. 4, no. 6, pp. 63-71, 2017.
[CrossRef] [Google Scholar] [Publisher Link]
[23] Thomas R. Rybolt, and Robert C. Mebane, “Economical High-Temperature Water Bath Control and Monitoring with a Sous Vide Cooking Device,” Journal of Chemical Education, vol. 95, no. 8, pp. 1402-1405, 2018.
[CrossRef] [Google Scholar] [Publisher Link]
[24] Qun Wei, So-Myoung Kang, and Jae Ho Lee, “Designing a Smart Bath Assistive Device Based on Measuring Inner Water Temperature for Bathing Temperature Monitoring,” Sensors, vol. 20, no. 8, pp. 1-12, 2020.
[CrossRef] [Google Scholar] [Publisher Link]
[25] T. Kativa et al., “Temperature Control Water Bath System Using PID Controller,” International Journal of Applied Engineering Research, vol. 10, no. 4, pp. 3443-3446, 2015.
[Google Scholar] 
[26] Qahtan A. Mahmood et al., “PID Temperature Control of Demineralized Water Tank,” IOP Conference Series: Materials Science and Engineering. vol. 454, 2018.
[CrossRef] [Google Scholar] [Publisher Link]
[27] Jafar Tavoosi, “An Experimental Study on Inverse Adaptive Neural Fuzzy Control for Nonlinear Systems,” International Journal of Knowledge-Based and Intelligent Engineering Systems, vol. 24, no. 2, pp. 135-143, 2020.
[CrossRef] [Google Scholar] [Publisher Link]
[28] Ashok Kumar Goel, Suresh Chandra Saxena, and Surekha Bhanot, “A Genetic Based Neuro-Fuzzy Controller for Thermal Processes,” Journal of Computer Science and Technology, vol. 5, no. 1, pp. 37-43, 2005.
[Google Scholar] [Publisher Link]
[29] Oussama Maroufi, Abdelghani Choucha, and Lakhdar Chaib, “Hybrid Fractional Fuzzy PID Design for MPPT-Pitch Control of Wind Turbine-Based Bat Algorithm,” Electrical Engineering, vol. 102, pp. 2149-2160, 2020.
[CrossRef] [Google Scholar] [Publisher Link]
[30] Lu Liu, Dingyu Xue, and Shuo Zhang, “General-Type Industrial Temperature System Control Based on Fuzzy Fractional-Order PID Controller,” Complex & Intelligent Systems, vol. 9, pp. 2585-2597, 2021.
[CrossRef] [Google Scholar] [Publisher Link]